The wallboard in my stairwell is bowing outward and has developed a horizontal crack (not along tape line).
-
JL Spring & Associates on Jul 10, 2011Hi JM, I'd start right where the bow is and above. I'd take a stud finder and cut an opening next to a support and nearest the bow, get a good light and see what you can in a one foot square hole. I'm sure you know to cut the outline of the hole as square as possible and angle your rock saw or utility knife blade on as close to a 45 degree angle all around...it makes it easier to re-set the "plug" in the hole... Look as high up as you can and use a mirror if needed to see if there's any signs of water seepage...let us know what you find and take some digital pix to upload so we all can advise intellegently! Hope this helps out a little... JLHelpful Reply
-
-
Woodbridge Environmental Tiptophouse.com on Jul 11, 2011What has happend here is common, The framing of the house has shrunk. To understand this a bit more you need to undertand how wood shrinks A wood board when it drys shrinks in demension on all sides The most being the wide side. such as a 2 x 10 x 8 with 2 inch thick, 10 inches wide, and 8 feet long. The 10 inch side will loose as much as a 1/4 inch. Knowing that you need to understand how a new home is typically constructed. This is western platform style. We set boards flat on foundation. The lay them on edge for floor joists, . Then lay them flat on bottom of wall Stand them up on end for walls then lay them flat on top and start all over again. Now what happens is the boards that are laying on edge for floor or to support 2nd level floor again are the ones that shrink the most. In a stair well the floor is removed to get to the next level, But the boards along the wall are still set on their edges. What happens here is they shrink and the wall board, plaster, plywood or what ever covers this framing does not. The result is the wall bows out. Ideally they should have framed this area with engineered lumber which does not shrink and cause this issue. Also when they cover the outside wall the contractor leaves a space between the plywood and does not seam directly over this area but just next to it so the plywood does not bow on the outside causing the same issue as inside. The fix is to cut the sheetrock and leave a small gap, then rescrew flat and finish. Most of the movement takes place within the first year so you should be good to go after that.Helpful Reply
-
-
Woodbridge Environmental Tiptophouse.com on Jul 15, 2011I have attached some photos of a Church I did work in about a year ago that provides some samples of what happens not only if you build incorrectly but it shows how in this case the outside bows out due to the settlement of the structure. The same thing can happen inside a wall like a staircase that is next to this area. This was an addition in which another contractor installed TGI joists without properly running a engineered band joist or adding any supports to prevent sagging of the floor. Those of you that are in the business will get a kick out of just how bad they constructed this building. You will also see some of the repairs that we did to help stop the settlement. We could not jack the addition up, but at least we stopped if from getting any worse.Helpful Reply
-
Related Discussions
Getting rid of wild day lilies
Our yard is covered with wild (I assume, since we never planted them)day lilies which have taken over our yard. Short of blasting them with Roundup, is there anything... See more
How do I clean dull vinyl siding?
I've had my vinyl siding power washed, but it is still dull, like oxidized or something. Is there a cleaner I can use?
whats the cheapest and most efficient way to clean mildew from vinyl siding on a doublewide mobile home?on a budget
How to remove green mold and/or stains along vinyl siding of our house
Well, we did bad!!!! Having scrubs like hemlocks, and other flowering (forsythea) evergreen-like lower plans on the north face of our home has left green stains on si... See more
What can I do about north Florida lawn weeds in the fall?
What is the most effective way to deal with Florida lawn weeds during the fall season? Additionally, what recommendations do you have for the best year-round lawn car... See more
Can you put a bar of soap in a toilet tank?
I am always looking for a good cleaning hack and came across one where a lady put a bar of soap in the toilet tank. Before I try this out, I was wondering if it could... See more